Chrysler Town & Country Recalls
Search for recalls by car
Make selection is required
NHTSA safety recall results (34)
Recall information provided by National Highway Traffic Safety Administration
Equipment: Electrical: Air conditioner
2010-11-07
10V611000
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK AT THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
View details Hide details
Seats
2010-07-27
10V338000
DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.
View details Hide details
Electrical system: Wiring
2010-06-01
10V235000
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY THROUGH SEPTEMBER 2007. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
View details Hide details
Structure: Body
2010-04-09
10V148000
THE BRAUN CORPORATION IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 CHRYSLER TOWN & COUNTRY AND DODGE CARAVAN COMMERCIAL ENTERVANS WHICH WERE ALTERED BY BRAUN BETWEEN JANUARY 21, 2009 AND MARCH 19, 2010. DURING CONVERSION, THE CHASSIS WAS RAISED AND THE FLOOR WAS LOWERED TO ACCOMMODATE WHEELCHAIR ACCESSIBILITY FEATURES. IN RAISING THE CHASSIS, THE FUEL FILL PIPE COMES INTO CLOSER PROXIMITY TO THE LEFT REAR TIRE. IN ROUGH OR AGGRESSIVE DRIVING SITUATIONS, THE TIRE MAY INTERMITTENTLY CONTACT THE FUEL FILL PIPE.
CONTACT BETWEEN THE TIRE AND FUEL FILL PIPE MAY WEAR A HOLE IN ONE OR THE OTHER COMPONENTS OVER TIME. THIS MAY RESULT IN LOSS OF VEHICLE CONTROL IN THE EVENT OF TIRE PRESSURE LOSS, OR A VEHICLE FIRE IN THE EVENT THE FUEL PIPE IS COMPROMISED.
BRAUN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT BRAUN TOLL-FREE AT 1-800-488-0359.
View details Hide details
Air bags
2010-01-11
10V008000
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
View details Hide details
Service brakes, hydraulic
2009-09-11
09V351000
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
View details Hide details
Electrical system: Fuses and circuit breakers
2009-02-03
09V046000
CHRYSLER IS RECALLING 13,350 MY 2009 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. UNUSED ELECTRICAL CONNECTORS FOR THE BLIND SPOT DETECTION SYSTEM MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS.
IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTORS COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
DEALERS WILL SEAL THE POWER CIRCUIT AT THE SUBJECT CONNECTOR AND REPLACE THE FUSE FOR THIS CIRCUIT IF NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
View details Hide details
Exterior lighting: Headlights
2008-08-12
08E053000
EAGLE EYES IS RECALLING 404,546 HEADLAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE HEADLAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EAGLE EYES WILL NOTIFY OWNERS AND OFFER CONPLIANT REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER/OCTOBER 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
View details Hide details
Air bags: Frontal: Sensor/control module
2007-05-01
07V192000
CERTAIN MINIVANS ARE BEING RECALLED IN STATES WHICH USE LARGE AMOUNTS OF SALT FOR ROAD DE-ICING, TO REPLACE THEIR UP FRONT (UF) AIR BAG SENSORS. UF SENSORS WITH BRASS BUSHINGS MAY CORRODE AND CRACK ALLOWING WATER TO ENTER THE SENSOR, CAUSING IT TO FAIL, ILLUMINATING THE AIR BAG WARNING LIGHT.
UF SENSORS PROVIDES ENHANCED AIR BAG PERFORMANCE IN CERTAIN TYPES OF FRONTAL CRASHES. IN ONE OF THESE CRASHES, WITH ONE OR BOTH OF THE VEHICLE'S UF SENSORS INOPERATIVE, THE OCCUPANTS WILL NOT BENEFIT FROM THE ENHANCED AIR BAG PROTECTION THAT THESE SENSORS WOULD PROVIDE.
IN STATES THAT USE LARGE AMOUNTS OF ROAD SALT, INCLUDING MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, KENTUCKY, NORTH DAKOTA, SOUTH DAKOTA, UTAH, NEBRASKA, KANSAS, ALASKA AND THE DISTRICT OF COLUMBIA, DAIMLERCHRYSLER WILL NOTIFY OWNERS AND REPLACE THE SUPPLEMENTAL UF AIR BAG SENSORS THAT CONTAIN BRASS BUSHINGS WITH UF SENSORS CONTAINING STEEL BUSHINGS AND HOUSINGS MOLDED OF CRASTIN MATERIAL. IN THE OTHER STATES, DAIMLERCHRYSLER WILL NOTIFY OWNERS AND WILL PROVIDE LIFETIME FREE REPLACEMENT OF ANY UF SENSOR THAT FAILS. OWNERS ARE REMINDED TO SEEK IMMEDIATE REPAIR IN THE EVENT THEIR AIR BAG WARNING LIGHT IS ILLUMINATED. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
View details Hide details
Visibility
2006-03-08
06V067000
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.